2019 Toyota Tundra Common Problems & Defect Telemetry
Authoritative defect intelligence synthesized from 72 verified NHTSA owner complaints, 10 federal safety recalls, and interquartile failure mileage telemetry.
The 2019 Toyota Tundra receives a 5.6/10 MazicBay Reliability Index based on 72 verified NHTSA federal complaints and 10 safety recalls. The primary reported failure mode is Fuel Pump Pressure Loss & Fuel Delivery Defect Reports with a median failure point at 33,400 miles (IQR: 33,400 – 33,400 mi). Out-of-warranty repairs benchmark at $650 – $1,250 .
6 complaints / 10k sold
Verified US federal records
Crash, fire & stall audit
10 Active / Free Remedies
Top Reported Problem Clusters (7)
Fuel Pump Pressure Loss & Fuel Delivery Defect Reports
- Sudden loss of propulsion power at highway speeds
- Extended engine cranking / failure to restart
- Fuel odor near fuel tank / engine bay
“We had just exited the interstate when my Toyota Tundra stopped. We had it towed to the closest Toyota dealer. We had to have fuel pump replaced. They said the previous year Tundra was recalled for this issue, but ours was not. I just found out that some of the 2019 models had...”
“The contact owns a 2019 Toyota Tundra. The contact stated that while starting the vehicle, the engine sounded rough. The check engine warning light was illuminated. The vehicle was turned off and failed to restart. The vehicle was towed to an independent mechanic, where the EC...”
“My toyota tundra is having issues with the fuel pump. It is saying I am using e85 fuel when that is not the case. As a result I am having issues with cold start. There are recalls however I am being told that my truck is listed among them despite having the same issue.”
Service Brakes, ABS Actuator & Master Cylinder Reports
- Spongy or hard brake pedal travel
- ABS / Brake warning light illuminated
- Extended stopping distance / pedal vibration
“Intermittent message displaying "Trailer Brakes Disconnected" while towing. Trailer lights continued to operate even while message was displayed. On average trailer connected and disconnected every 2-3 minutes”
“Keep getting the messages "Trailer brake error, if towing come to a stop with manual controls" And "Pre-collision system malfunction" The messages go away usually after restarting the vehicle but eventually comes back on”
“The contact owns a 2019 Toyota Tundra. The contact stated that while replacing the shocks, the contact noticed that the shocks were oily. The vehicle was taken to the local dealer for warranty repair, and the contact was informed that the brake pads on the rear axle were soake...”
Electrical Parasitic Drain, Infotainment & Harness Reports
- Unexplained battery drain after sitting overnight
- Infotainment display / instrument cluster blackouts
- Accessory malfunction / alternator fault warnings
“The contact owns a 2019 Toyota Tundra. The contact stated that while parked for 5-10 minutes, the contact noticed a burning plastic odor, and upon looking up moments later, the contact noticed flames coming from the driver's side headlight, and the flames were 6 inches above t...”
“Intermittent message displaying "Trailer Brakes Disconnected" while towing. Trailer lights continued to operate even while message was displayed. On average trailer connected and disconnected every 2-3 minutes”
“Keep getting the messages "Trailer brake error, if towing come to a stop with manual controls" And "Pre-collision system malfunction" The messages go away usually after restarting the vehicle but eventually comes back on”
Engine Stalling, Oil Consumption & Cooling Defect Reports
- Engine sudden stall / hesitation while driving
- Abnormal oil burning / consumption
- Check Engine Light (MIL) flashing
- Engine overheating / coolant loss
“The contact owns a 2019 Toyota Tundra. The contact stated that while starting the vehicle, the engine sounded rough. The check engine warning light was illuminated. The vehicle was turned off and failed to restart. The vehicle was towed to an independent mechanic, where the EC...”
“The contact owns a 2019 Toyota Tundra. The contact stated that while replacing the shocks, the contact noticed that the shocks were oily. The vehicle was taken to the local dealer for warranty repair, and the contact was informed that the brake pads on the rear axle were soake...”
“The contact owns a 2019 Toyota Tundra. The contact stated while attempting to start the vehicle at the residence, the contact stated that the engine was shaking abnormally. No warning lights were illuminated. The contact stated that a dealer was contacted. The vehicle was take...”
Electric Power Steering Assist & Suspension Noise Reports
- Sudden loss of electric power steering assist
- Steering wheel pull or highway wander
- Clunking / knocking noise over bumps
“I had to have the steering rack assembly replaced in my vehicle due to a leak. This is one of the complaints and a recall but I never got a notification.”
“I took my vehicle in for scheduled maintenance. During the safety inspection the Toyota authorized tech advised me about a serious safety issue with rust on the undercarriage of my vehicle. He advised that the control arms as well as sway bars and suspension , shocks, struts h...”
“My son was driving to Mineral Wells to get something to eat on Wednesday 11/17/21 at 8:00 at night on FM 52 South. All of a sudden the steering wheel falls in his lap. He picked it up and shoved it onto the column and was able to steer the truck onto the side of the road witho...”
Airbag Occupant Detection & Inflator Defect Reports
- SRS Airbag warning lamp illuminated
- Passenger occupant classification sensor failure
- Seat belt retractor lockup
“The contact owned a 2019 Toyota Tundra. The contact stated that while driving at approximately 45 MPH, an oncoming vehicle did not obey a stop sign and proceeded to crash into the rear driver's side of the contact's vehicle. As a result, the contact lost control of the vehicle...”
“The contact owns a 2019 Toyota Tundra. The contact stated that while driving approximately 75 mph, a 2008 Lincoln struck the rear passenger side of her vehicle which caused her vehicle to tail spin and crash into the guardrail. The vehicle continued to tailspin. The air bags d...”
“The electrical system malfunctioned, causing all warning lamps on the dashboard to light up. Because this happened while I was driving, I do believe that this electrical issue caused safety concerns for others on the road. The taillights went out first, seconds later, all rema...”
Transmission Hesitation, Hard Shifting & Slipping Reports
- Hard gear shifts / delayed engagement into Drive/Reverse
- Transmission shudder / jerking under acceleration
- Transmission slipping between gears
“DRIVING WITH CRUISE CONTROL AT 30 MPH, THE ENGINE LIGHT TURNED ON , AND SUDDENLY THE ENGINE SHUT DOWN, NO BRAKES AND NO POWER STEERING. I WENT TO TURN RIGHT AT THE NEAREST AVAILABLE SIDE STREET SO I WOULD GET OUT OF THE WAY OF TRAFFIC. AS I WAS TRYING TO TURN RIGHT, THE STEERI...”
“VEHICLE PARKED ON BOAT LAUNCHING RAMP 25-30% SLOPE CONCRETE SURFACE WITH 24 FOOT ALUMINUM TRAILER IN TOW; BOAT OFF TRAILER, TRUCK FACING AWAY FROM WATER, TRAILER CLOSEST TO WATER. SUNNY, RAMP WAS DAMP, WITH SOME WOOD AND AQUATIC VEGETATION ON RAMP. VEHICLE WAS IN 2 WHEEL DRIVE...”
Official NHTSA Safety Recalls (10)
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
STEERING:HYDRAULIC POWER ASSIST SYSTEM
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
EXTERIOR LIGHTING:HEADLIGHTS
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2021 Tundra vehicles. The headlight electrical circuits may power the high and low beams simultaneously, which could overheat the electrical connector.
EXTERIOR LIGHTING:TURN SIGNAL
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2020 Toyota Tundra vehicles equipped with LED headlight assemblies. Due to a wiring error, the front turn signals may not flash brightly enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
STEERING:HYDRAULIC POWER ASSIST SYSTEM
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain JTEKT power steering gear assembly service parts for 2007-2021 Tundra and 2008-2022 Sequoia, part numbers 44250-0C160, 44250-0C131, 44250-0C170, and 11250-0C121. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on January 13, 2020. On March 4, 2020, Toyota expanded the recall to include certain 2014-2015 Toyota 4Runner and Land Cruiser, 2018 Avalon, Corolla, 2014 FJ Cruiser, 2017 Sienna and Lexus 2018 ES 350, 2018-2019 GS 300, 2013-2014 GS350, 2014-2015 GX 460, IS 350 and LX 570, 2014 IS F, 2018-2019 IS 350, LC 500H and LS 500H, 2013-2015 LS 460, 2015 NX 200T and RC350, 2017 RC 200T and RX 350. Toyota also removed the 2018-2019 Toyota 4Runner and Land Cruiser and 2018-2019 Lexus GX 460 and LX 570 and 2019 NX300 from inclusion in this recall. On March 19, 2020, Toyota expanded the recall to include 2015 Lexus GS350 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
ELECTRICAL SYSTEM:SOFTWARE
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tundra and Sequoia vehicles and 2019 Toyota Avalon and Avalon Hybrid vehicles. The air bag electronic control unit (ECU) may erroneously detect a fault during the vehicle start-up self check. If this occurs, the ECU may not deploy the airbags as intended, in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection," and 214, "Side Impact Protection."
EQUIPMENT:OTHER:LABELS
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tundra vehicles. The accessory all-weather floormats may have been counted twice when creating the load carrying capacity modification label, resulting in the capacity modification label incorrectly overstating the additional weight by 10 pounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
EQUIPMENT:OTHER:LABELS
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Toyota Tundra standard and long bed trucks equipped with a spray-in bed liner. The load carrying capacity modification label may have been incorrectly calculated. If the label is followed, the vehicle may be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
EQUIPMENT:OTHER:LABELS
Summary: Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Pre-Purchase Inspection Checklist for 2019 Toyota Tundra
Before purchasing a used 2019 Toyota Tundra, perform the following targeted inspections based on reported federal defect patterns:
Scan the OBD-II port under the dash for pending freeze-frame codes (e.g. P0300 misfires, P0087 fuel rail pressure, P0420 catalytic efficiency).
Test vehicle at low-speed stop-and-go and highway merges. Check for delayed reverse engagement or gear shift shudder between 2nd and 3rd gears.
Verify that all 10 NHTSA safety recall campaigns have been performed by an authorized dealership using the VIN.
Ensure the instrument cluster, center screen, and auxiliary charging ports operate with stable 12.0V–14.4V alternator voltage.
Defect & Reliability Q&A: 2019 Toyota Tundra
Is the 2019 Toyota Tundra a reliable used car?
The 2019 Toyota Tundra earns a 5.6/10 MazicBay Reliability Index based on 72 federal owner reports. Vehicles maintained under factory service schedules exhibit strong longevity past 150,000 miles.
What is the most frequent defect reported on the 2019 Toyota Tundra?
The leading complaint category is Fuel Pump Pressure Loss & Fuel Delivery Defect Reports, with a median failure point around 33,400 miles (IQR: 33,400 – 33,400 mi).
Are there free recall repairs available for the 2019 Toyota Tundra?
Yes, the NHTSA records 10 safety recall campaign(s) for this model year. All safety recalls are performed 100% free of charge by authorized franchise dealerships regardless of vehicle warranty status.