P0455 on Jeep: Symptoms, Causes & DIY Fix
Official technical diagnostic wire for fault code P0455 (P0455: Evaporative Emission Control System Leak Detected (Gross Leak)) specifically affecting Jeep vehicles (Grand Cherokee, Wrangler, Gladiator, Compass).
1. Symptoms of P0455 on Jeep
When the Engine Control Module (ECM/PCM) on your Jeep logs fault code P0455, drivers commonly observe:
2. Most Likely Causes on Jeep
Historical warranty claims and technical repair bulletins for Jeep point to the following failure distribution:
3. Step-by-Step DIY Repair Guide for Jeep
Remove gas cap, inspect rubber O-ring for cracks, tighten until it clicks 3 times. on Jeep vehicles (Grand Cherokee, Wrangler).
If the cap rubber is dried or cracked, replace with genuine OEM cap ($15). on Jeep vehicles (Grand Cherokee, Wrangler).
Disconnect electrical plug and vacuum hose. Apply 12V; verify valve seals tight when unpowered. on Jeep vehicles (Grand Cherokee, Wrangler).
Check vent valve for road salt corrosion or spider nest clogs. on Jeep vehicles (Grand Cherokee, Wrangler).
Pump mineral oil smoke into EVAP port to reveal any hairline cracked lines. on Jeep vehicles (Grand Cherokee, Wrangler).
P0455 Guides by Jeep Model
Select your specific Jeep model below for exact OBD-II DLC port locations, wiring diagrams, and engine displacement specs:
Other Common Diagnostic Codes on Jeep
Troubleshoot other high-frequency Check Engine Light fault codes reported across Jeep vehicles:
4. Jeep P0455 FAQs
What causes code P0455 to trigger on a Jeep?
On Jeep vehicles, P0455 is most frequently caused by Missing, loose, or cracked gas cap seal or Faulty EVAP purge control solenoid. Factory sensor degradation or wiring harness wear near the engine bay are common factors.
Can I safely drive my Jeep with code P0455?
Yes. Completely safe to drive, but emissions test will fail. Given that P0455 carries a Low severity rating on Jeep vehicles, we advise performing diagnostic scanning via the OBD-II port before extended driving.
How much does it cost to fix P0455 on a Jeep?
DIY replacement parts typically range between $15 - $250 (DIY: $15 - $50). If serviced at an authorized Jeep dealership, expect an additional $120–$250 in professional labor based on their $125/hr hourly rate.