P0355 on Volvo EX90
Factory diagnostic protocol and troubleshooting wire for fault code P0355 specifically for the Volvo EX90 (2024–2026, Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh)).
1. Symptoms of P0355 on Volvo EX90
When the Engine Control Module (ECM/PCM) on your Volvo EX90 (Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh)) logs fault code P0355, drivers commonly observe:
2. Most Likely Causes on Volvo EX90
Historical warranty claims and technical repair bulletins for Volvo EX90 point to the following failure distribution:
3. Step-by-Step DIY Repair Guide for Volvo EX90
Connect an OBD-II scan tool and record freeze frame sensor telemetry for code P0355 to note engine RPM, load, and voltage when the fault triggered. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Inspect the electrical connector and wiring harness related to P0355 for chafing, corrosion, moisture, or pin push-out. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Measure circuit voltage supply (12V B+ or 5V reference) and sensor/actuator resistance according to factory repair manual specifications. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Install a new OEM-grade replacement part, torque fasteners to factory spec, and ensure electrical locking tabs click firmly. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Clear all stored DTCs from vehicle memory and perform an OBD-II drive cycle to confirm the diagnostic monitor resets to 'Ready'. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Equipment for Diagnosing Volvo EX90 (P0355)
Direct-Fit Laser Iridium Spark Plugs (Set of 4/6)
Pre-gapped iridium spark plugs engineered to restore smooth combustion on Volvo EX90.
Magnetic Swivel Spark Plug Socket Set
360-degree magnetic swivel socket prevents ceramic plug cracks inside deep engine spark wells.
BlueDriver Bluetooth Pro OBDII Scan Tool
Reads and clears enhanced codes (ABS, Airbag, Transmission, Engine) & live freeze-frame telemetry on phone.
Other Common Fault Codes on Volvo EX90
Frequently diagnosed powertrain, emissions, and sensor trouble codes logged on the Volvo EX90:
4. Volvo EX90 P0355 FAQs
What causes code P0355 to trigger on a Volvo EX90?
On the Volvo EX90 (Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh)), P0355 is most frequently caused by Dead Cylinder 5 ignition coil or Wiring damage.
Where is the OBD-II port located on my Volvo EX90?
On the Volvo EX90, the 16-pin DLC diagnostic connector is located Driver footwell lower OBD interface. Plug in any standard OBD-II scanner with the ignition in the ON position to read freeze-frame parameters.
Can I safely drive my Volvo EX90 with code P0355?
No. Cylinder 5 ignition coil dead. Given that P0355 carries a Critical severity rating, we advise avoiding heavy towing or aggressive throttle inputs until sensor readings are verified.