P0125 on Volvo EX90
Factory diagnostic protocol and troubleshooting wire for fault code P0125 specifically for the Volvo EX90 (2024–2026, Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh)).
1. Symptoms of P0125 on Volvo EX90
When the Engine Control Module (ECM/PCM) on your Volvo EX90 (Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh)) logs fault code P0125, drivers commonly observe:
2. Most Likely Causes on Volvo EX90
Historical warranty claims and technical repair bulletins for Volvo EX90 point to the following failure distribution:
3. Step-by-Step DIY Repair Guide for Volvo EX90
Check that engine coolant is at full mark and no external radiator or hose leaks exist. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Start cold engine and watch ECT climb. If it plateaus below 170°F (77°C) while driving, thermostat is stuck open. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Drain 1 gallon of coolant, remove thermostat housing bolts, install new OEM temperature-rated thermostat (typically 180°F–195°F) with jiggle valve at 12 o'clock. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Fill cooling system with 50/50 prediluted coolant, run engine with spill-free funnel to purge air bubbles. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Verify scan tool Fuel System Status changes from 'Open Loop' to 'Closed Loop' within 5 minutes. on the Volvo EX90 equipped with Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh).
Equipment for Diagnosing Volvo EX90 (P0125)
OEM Thermostat & Gasket Assembly
Direct-replacement thermostat calibrated to factory operating temperature for Volvo EX90.
AstroAI Auto-Ranging Digital Multimeter
Essential for testing 0.1V–5.0V sensor reference signals, ground continuity (<0.20Ω), and harness resistance.
BlueDriver Bluetooth Pro OBDII Scan Tool
Reads and clears enhanced codes (ABS, Airbag, Transmission, Engine) & live freeze-frame telemetry on phone.
Other Common Fault Codes on Volvo EX90
Frequently diagnosed powertrain, emissions, and sensor trouble codes logged on the Volvo EX90:
4. Volvo EX90 P0125 FAQs
What causes code P0125 to trigger on a Volvo EX90?
On the Volvo EX90 (Twin Motor AWD EV (402HP / Performance 510HP / 111 kWh)), P0125 is most frequently caused by Thermostat stuck open or opening prematurely or Low engine coolant level / air pocket around ECT sensor.
Where is the OBD-II port located on my Volvo EX90?
On the Volvo EX90, the 16-pin DLC diagnostic connector is located Driver footwell lower OBD interface. Plug in any standard OBD-II scanner with the ignition in the ON position to read freeze-frame parameters.
Can I safely drive my Volvo EX90 with code P0125?
Yes, for short distances. Fuel economy will drop 15–25% as the engine remains trapped in open-loop enrichment. Given that P0125 carries a Medium severity rating, we advise avoiding heavy towing or aggressive throttle inputs until sensor readings are verified.