2020 Chrysler Voyager Common Problems & Defect Telemetry
Authoritative defect intelligence synthesized from 12 verified NHTSA owner complaints, 1 federal safety recalls, and interquartile failure mileage telemetry.
The 2020 Chrysler Voyager receives a 7.9/10 MazicBay Reliability Index based on 12 verified NHTSA federal complaints and 1 safety recalls. The primary reported failure mode is Engine Stalling, Oil Consumption & Cooling Defect Reports with a median failure point at 74,260 miles (IQR: 68,130 – 80,389 mi). Out-of-warranty repairs benchmark at $950 – $3,200 .
8 complaints / 10k sold
Verified US federal records
Crash, fire & stall audit
1 Active / Free Remedies
2020 Voyager Failure Distribution by Vehicle Subsystem
Top Reported Problem Clusters (6)
Engine Stalling, Oil Consumption & Cooling Defect Reports
- Engine sudden stall / hesitation while driving
- Abnormal oil burning / consumption
- Check Engine Light (MIL) flashing
- Engine overheating / coolant loss
“Intermittent power steering failure while driving. Wife cannot turn it causing near misses during turns. Steering restored IF turn off ignition and restart engine.”
“All of a sudden the van starts running very hard, trying to stall, the stop/start warning comes on, engine light comes on and the van has a lot of trouble accelerating. If the van will stall in the middle of the road it would put me, my kids and other cars around me at risk, e...”
“Car completely stopped . After 2 months of checking the car I was told the motor is corroded. Bought the vehicle 2022 with no reports of any incidents”
Electric Power Steering Assist & Suspension Noise Reports
- Sudden loss of electric power steering assist
- Steering wheel pull or highway wander
- Clunking / knocking noise over bumps
“Intermittent power steering failure while driving. Wife cannot turn it causing near misses during turns. Steering restored IF turn off ignition and restart engine.”
“Power steering stops working while driving. Very difficult to turn vehicle Intermittent Failures with no pattern. Local dealer replaced auxiliary battery yesterday in attempt to correct problem but did not solve the problem. Bought used 92000 miles.”
“There is a sticking of the steering wheel when I have a slow turn to the right or I am on a gradual curve to the right. The steering wheel "locks" temporarily and I have to tug to the left to get it to move back to the center position. I took note of an NTHSA warning about 201...”
Electrical Parasitic Drain, Infotainment & Harness Reports
- Unexplained battery drain after sitting overnight
- Infotainment display / instrument cluster blackouts
- Accessory malfunction / alternator fault warnings
“Power steering stops working while driving. Very difficult to turn vehicle Intermittent Failures with no pattern. Local dealer replaced auxiliary battery yesterday in attempt to correct problem but did not solve the problem. Bought used 92000 miles.”
“I was turning left into a parking lot when my 2020 Voyager steering stopped working while it started to show all warning lights and the wipers went on, then it went dead, had to be towed on a flatbed to the dealership, and after 4 weeks with no solution in sight, I decided to ...”
“Start stop light comes on and vehicle goes to limp mode or dies while driving, Check engine light also comes on.”
Transmission Hesitation, Hard Shifting & Slipping Reports
- Hard gear shifts / delayed engagement into Drive/Reverse
- Transmission shudder / jerking under acceleration
- Transmission slipping between gears
“While drivng with the cruise control engaged and encountering a downhill speed increase of about 5 MPH, the transmission kicks down to engage engine breaking. However as the process starts, first the engine revs and will increase vehicle speed by about 5 MPH. An example is cru...”
Service Brakes, ABS Actuator & Master Cylinder Reports
- Spongy or hard brake pedal travel
- ABS / Brake warning light illuminated
- Extended stopping distance / pedal vibration
“The contact owns a 2020 Chrysler Voyager. The contact stated that while driving at an undisclosed speed, the contact was not able to brake even though the brake pedal was fully depressed. The contact crashed into some logs because the brakes failed. The air bags did not deploy...”
Airbag Occupant Detection & Inflator Defect Reports
- SRS Airbag warning lamp illuminated
- Passenger occupant classification sensor failure
- Seat belt retractor lockup
“The contact owns a 2020 Chrysler Voyager. The contact stated that while driving at an undisclosed speed, the contact was not able to brake even though the brake pedal was fully depressed. The contact crashed into some logs because the brakes failed. The air bags did not deploy...”
Official NHTSA Safety Recalls (1)
AIR BAGS:SIDE/WINDOW:CURTAIN
Summary: Chrysler (FCA US, LLC) is recalling certain 2020-2023 Pacifica and 2020-2021, 2023 Voyager vehicles. An improperly secured connector for the side curtain air bags may prevent the air bags from deploying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 226, "Ejection Mitigation."
Tools for Diagnosing the 2020 Chrysler Voyager
Reads & clears all DTC codes including ABS, SRS, TPMS. Live sensor data with freeze frames. Works on all 1996+ vehicles.
Pre-gapped OEM-spec iridium plugs restore smooth combustion on misfiring cylinders.
Affiliate Disclosure: MazicBay participates in the Amazon Associates Program. We may earn a commission from qualifying purchases at no extra cost to you. Recommendations are based on vehicle compatibility data and editorial review.
Pre-Purchase Inspection Checklist for 2020 Chrysler Voyager
Before purchasing a used 2020 Chrysler Voyager, perform the following targeted inspections based on reported federal defect patterns:
Scan the OBD-II port under the dash for pending freeze-frame codes (e.g. P0300 misfires, P0087 fuel rail pressure, P0420 catalytic efficiency).
Test vehicle at low-speed stop-and-go and highway merges. Check for delayed reverse engagement or gear shift shudder between 2nd and 3rd gears.
Verify that all 1 NHTSA safety recall campaigns have been performed by an authorized dealership using the VIN.
Ensure the instrument cluster, center screen, and auxiliary charging ports operate with stable 12.0V–14.4V alternator voltage.
Defect & Reliability Q&A: 2020 Chrysler Voyager
Is the 2020 Chrysler Voyager a reliable used car?
The 2020 Chrysler Voyager earns a 7.9/10 MazicBay Reliability Index based on 12 federal owner reports. Vehicles maintained under factory service schedules exhibit strong longevity past 150,000 miles.
What is the most frequent defect reported on the 2020 Chrysler Voyager?
The leading complaint category is Engine Stalling, Oil Consumption & Cooling Defect Reports, with a median failure point around 74,260 miles (IQR: 68,130 – 80,389 mi).
Are there free recall repairs available for the 2020 Chrysler Voyager?
Yes, the NHTSA records 1 safety recall campaign(s) for this model year. All safety recalls are performed 100% free of charge by authorized franchise dealerships regardless of vehicle warranty status.